:: Volume 6, Issue 1 (9-2017) ::
ieijqp 2017, 6(1): 71-79 Back to browse issues page
Solid-state Transformer Inrush Current Limiter for Power Quality Improvement
Teymoor Ghanbari * 1, Nima Tashakor , Ehsan Bagheri
Abstract:   (4732 Views)

Excessive transient inrush current of the power transformers has some negative impacts such as: transformer lifetime reduction, mal-operation of the relevant protections, and power quality degradation. In some cases, the energization impact on power quality may lead to catastrophic damages to the system such as offshore stations. Therefore, suppression of inrush current is vital in such applications.

In this paper, a new Solid-State Inrush Current Limiter (SSICL) is proposed for medium voltage power transformers with the capability of integration with already existing circuit-breakers. The proposed SSICL consists of three similar sets of bidirectional semiconductor switch and an inrush current limiter resistor. Using a Kalman Filter based strategy, transformer inrush current is suppressed during magnetization process. In fact, built up profile of the inrush current is dictated in accordance with the estimated current by a slow dynamic Kalman filter. The proposed SSICL is simulated in MATLAB-SIMULINK and a single-phase experimental prototype of the limiter is implemented. The proposed control scheme was implemented using dsPIC30F4011. In order to evaluate the performance of the SSICL, some experiments were carried out. Simulation and Experimental results show that the proposed SSICL can considerably suppress inrush current of the transformer.

Keywords: Industrial transformers, Inrush current, Kalman Filter, Power Quality, Solid-state inrush current limiter.
Full-Text [PDF 1517 kb]   (1964 Downloads)    
Type of Study: Research | Subject: Special
Received: 2016/09/20 | Accepted: 2017/08/21 | Published: 2017/09/5
References
1. [1] M. Heathcote, J & P transformer book: Newnes, 2011.
2.  [2] C.-K. Cheng, J.-F. Chen, T.-J. Liang, and S.-D. Chen, "Transformer design with consideration of restrained inrush current," International Journal of Electrical Power & Energy Systems, vol. 28, pp. 102-108, 2006.
3.  [3] K. Smith, L. Ran, and B. Leyman, "Analysis of transformer inrush transients in offshore electrical systems," IEE Proceedings-Generation, Transmission and Distribution, vol. 146, pp. 89-95, 1999.
4.  [4] T. Ghanbari and E. Farjah, "Development of an efficient solid-state fault current limiter for microgrid," IEEE Transactions on Power Delivery, vol. 27, pp. 1829-1834, 2012.
5.  [5] T. Ghanbari, E. Farjah, and A. Zandnia, "Solid-state transient limiter for capacitor bank switching transients," IET Generation, Transmission & Distribution, vol. 7, pp. 1272-1277, 2013.
6.  [6] T. Ghanbari, E. Farjah, and A. Zandnia, "Development of a high-performance bridge-type fault current limiter," IET Generation, Transmission & Distribution, vol. 8, pp. 486-494, 2014.
7.  [7] J.-L. Shyu, "A novel control strategy to reduce transformer inrush currents by series compensator," in 2005 International Conference on Power Electronics and Drives Systems, 2005, pp. 1283-1288.
8.  [8] J.-F. Chen, T.-J. Liang, C.-K. Cheng, S.-D. Chen, R.-L. Lin, and W.-H. Yang, "Asymmetrical winding configuration to reduce inrush current with appropriate short-circuit current in transformer," IEE Proceedings-Electric Power Applications, vol. 152, pp. 605-611, 2005.
9.  [9] V. Molcrette, J.-L. Kotny, J.-P. Swan, and J.-F. Brudny, "Reduction of inrush current in single-phase transformer using virtual air gap technique," IEEE Transactions on Magnetics, vol. 34, pp. 1192-1194, 1998.
10.  [10] C.-K. Cheng, T.-J. Liang, J.-F. Chen, S.-D. Chen, and W.-H. Yang, "Novel approach to reducing the inrush current of a power transformer," IEE Proceedings-Electric Power Applications, vol. 151, pp. 289-295, 2004.
11.  [11] J. H. Brunke and K. J. Frohlich, "Elimination of transformer inrush currents by controlled switching. I. Theoretical considerations," IEEE Transactions on power delivery, vol. 16, pp. 276-280, 2001.
12.  [12] J. H. Brunke and K. J. Frohlich, "Elimination of transformer inrush currents by controlled switching. II. Application and performance considerations," IEEE Transactions on Power Delivery, vol. 16, pp. 281-285, 2001.
13. [13] O. A. Mahgoub, "Microcontroller-based switch for three-phase transformer inrush current minimization," in Power Electronics Congress, 1996. Technical Proceedings. CIEP'96., V IEEE International, 1996, pp. 107-112.
14.  [14] S. G. Abdulsalam and W. Xu, "A sequential phase energization method for transformer inrush current reduction—Transient performance and practical considerations," IEEE transactions on power delivery, vol. 22, pp. 208-216, 2007.
15.  [15] M. T. Hagh and M. Abapour, "DC reactor type transformer inrush current limiter," IET Electric Power Applications, vol. 1, pp. 808-814, 2007.
16.  [16] S. Madani, M. Rostami, G. Gharehpetian, and R. Haghmaram, "Inrush current limiter based on three-phase diode bridge for Y-yg transformers," IET electric power applications, vol. 6, pp. 345-352, 2012.
17.  [17] H.-T. Tseng and J.-F. Chen, "Voltage compensation-type inrush current limiter for reducing power transformer inrush current," IET electric power applications, vol. 6, pp. 101-110, 2012.
18.  [18] T. Ghanbari and E. Farjah, "Efficient resonant-type transformer inrush current limiter," IET electric power applications, vol. 6, pp. 429-436, 2012.
19.  [19] H.-C. Seo, C.-H. Kim, S.-B. Rhee, J.-C. Kim, and O.-B. Hyun, "Superconducting fault current limiter application for reduction of the transformer inrush current: a decision scheme of the optimal insertion resistance," IEEE Transactions on Applied Superconductivity, vol. 20, pp. 2255-2264, 2010.
20.  [20] M. Ahmed, G. Putrus, L. Ran, and R. Penlington, "Development of a prototype solid-state fault-current limiting and interrupting device for low-voltage distribution networks," IEEE transactions on power delivery, vol. 21, pp. 1997-2005, 2006.
21.  [21] Ghanbari, Teymoor. "Kalman filter based incipient fault detection method for underground cables." IET Generation, Transmission & Distribution 9.14 (2015): 19] Ghanbari, Teymoor. "Kalman filter based incipient fault detection method for underground cables." IET Generation, Transmission & Distribution 9.14 (2015): 1988-1997. 


XML   Persian Abstract   Print



Rights and permissions
Creative Commons License This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
Volume 6, Issue 1 (9-2017) Back to browse issues page